Objective: Build a Plice (plywood ice)

Cost: Less than $100

Materials:

One sheet rough 3/4" plywood
Two 16-foot 2x4s
Six 8-foot 2x4s
32 feet of 1x3 (give or take) in 24-inch pieces.
3-inch deck screws, 2-inch screws.

First, build a frame with the 16-foot 2x4s. It should be 16 feet long and 24 inches wide with 2x4s on theends. "Ladder frame" this with a 22-inch 2x4 every 12 inches. When on its side it will basically look like a small 24-inch wall.
Cut the plywood in half the long way, creating two 2x8-inch pieces. Take a little care, but a skill saw rip is fine.
Screw the plywood to the frame.
Cut the 1x3 (roughly, just about anything will work) into 24-inch pieces. Screw these "foothold" pieces on so the top edge of the piece is roughly below the framing pieces on the other side of the plywood.
Get a 1-inch drill, and drill through the plywood just above the horizontal foothold piece and into the "stud" piece of 2x4 on the back. Makes these holes deep. You'll likely hit a screw or nail or something, so use an old bit if possible.
Hang the plice so it won't fall over. Put a t2x10 between two trees, and hang it there if you want to be able to adjust the angle, or tie it directly to a tree if you want a vertical plice. There's lots of solutions out there!

Enjoy!

—Will Gadd

MORE STORIES

Engineered From Experience

ENGINEERED FROM EXPERIENCE

Our gear and apparel is made for mountain movement, featuring innovative designs and durable constructions....

READ ARTICLE
The Alpine Climbing Fit-Check

THE ALPINE CLIMBING FIT-CHECK

What to wear for alpine rock climbing.

READ ARTICLE
Gear for Alpine Sending

GEAR FOR ALPINE SENDING

What equipment to bring alpine rock climbing. 

READ ARTICLE
Hard Sends with Seb Bouin—El Gran Cabron

HARD SENDS WITH SEB BOUIN—EL GRAN CABRON

Watch BD Athlete Seb Bouin establish the hardest sport route in China.

READ ARTICLE
Black Diamond Guide To Headlamps

BLACK DIAMOND GUIDE TO HEADLAMPS

Your ultimate guide to lighting the way.

READ ARTICLE
What to Bring on a Trail Run

WHAT TO BRING ON A TRAIL RUN

The essentials for mountain running. 

READ ARTICLE
BD Guide To Climbing Pants

BD GUIDE TO CLIMBING PANTS

Focused on comfort and freedom of movement, built for the climbing life. 

READ ARTICLE
How to Choose a Hiking Pack

HOW TO CHOOSE A HIKING PACK

A guide to find the pack for your pursuit.

READ ARTICLE
Bouldering in Milho Verde

BOULDERING IN MILHO VERDE

BD Ambassador Eric Jerome shares about his experience from the little Brazilian bouldering town of...

READ ARTICLE
Packs and Vests for Moving Through the Mountains

PACKS AND VESTS FOR MOVING THROUGH THE MOUNTAINS

BD mountain athletes Joe Grant and Kelly Halpin guide us through their picks for trail...

READ ARTICLE
The New School Of Hard Rocks

THE NEW SCHOOL OF HARD ROCKS

BD Ambassador Ethan Salvo sounds off on why Squamish is yielding testpieces for the next...

READ ARTICLE
Making of the Zone Harness

MAKING OF THE ZONE HARNESS

A revolutionary design in performance and comfort.

READ ARTICLE
BFCL Episode 4: Drifter's Escape

BFCL EPISODE 4: DRIFTER'S ESCAPE

Watch Connor Herson establish the world’s hardest trad climb.

READ ARTICLE
How to Choose a Climbing Rope

HOW TO CHOOSE A CLIMBING ROPE

Tips for picking a new cord. 

READ ARTICLE
Making Of The Distance FKT Pole

MAKING OF THE DISTANCE FKT POLE

The next evolution of efficiency and endurance for mountain running.

READ ARTICLE